FESTO儲氣罐的構成:
空氣壓縮機的儲氣罐由封頭、筒體和附著在儲氣罐上的若干個接管組成，其封頭、筒體由板材彎制而成，包括筒體，罐體通過法蘭連接上封頭和下封頭，上橢圓形封頭外側分別設有與罐內相通的壓力表接口、出氣口、安全閥接口，筒體具有一儲氣腔，下封頭的底部設有排污閥，下封頭的外壁上設有支座；儲氣腔內設有脫水器，脫水器包括具有錐形底面的圓柱筒體，下封頭內壁上設有與圓柱筒體固定連接的固定支架，筒體上設有一伸入儲氣腔且沿圓柱筒體的切向連接于圓柱筒體上的進氣管，圓柱筒體的頂面設有導氣管，圓柱筒體的錐形底面的底部連接出水管，出水管與排污閥連接。 

FESTO儲氣罐的檢驗要求:
通常作為簡單壓力容器，空壓機儲氣罐一直被認為是比較安全的一種特種設備，但也存在一定的危險性，在設計、制造質量、安裝標準、運行上、管理上如果出現問題，不符合規定要求，將會埋下隱患，在使用中可能發生嚴重事故，造成人員傷亡、設備損壞。
FESTO儲氣罐在安裝前需報裝，安裝后按照特種設備要求進行辦理壓力容器使用證、進行定期檢驗，檢驗合格取得檢驗報告后，方可投入使用。按照儲氣罐的壓力級別、使用年限要進行定期檢驗，未經定檢合格的儲氣罐不得使用。儲氣罐的容積、壓力高低應符合設計標準，不能隨便配置，一臺空氣壓縮機配備一臺儲氣罐。地面空氣壓縮機站的儲氣罐應避免陽光直曬，儲氣罐必須有檢查孔，要定期清除罐內的油垢。

FESTO儲氣罐選型參數：
FESTO儲氣罐安裝空壓機之后，不僅能儲存壓縮空氣，減少由于壓縮機排氣不連續產生的壓力脈動，實現供氣和用氣的平衡，而且能降低壓縮空氣的溫度，減少過慮器和干燥劑的負荷。儲氣罐的選擇要注意如下問題：
1、殼體材料：儲氣罐屬于壓力容器，殼體常用的材料有Q235-B、16MnR、16MnDR三種。
2、儲氣罐總高：氣源房房體的高度在2.9米左右，考慮到氣源經常移動運輸，需要保持足夠的剛度和強度，底座高度一般在300mm，屋頂部做成斜坡，造成氣源房內的凈高為2米，所有設備不能超過2米，否則無法安裝。以2.5m³儲氣罐為例。